Full list of engine codes update

[bakerboy-2007]

Hi guys while crawling the Internet I stumbled across this in a post on another mitzi site (I apologise if it was a member I've ripped this from) however it's the best list of codes I've seen so thought I would share


Diagnostic Connector / OBDII port

Diagnostic codes allow us to see any errors the ECU has logged without connecting up an MUT-II diagnostic computer or a laptop with EVO Scan. All you need is a paper clip or similar piece of conductive wire, follow the procedure below to put the car in diagnostic mode, and then check the error codes you see against the list provided.



The connector looks this shape, and this is the pin configuration:


With the iginition on, but engine NOT running - ground Pin 1 to Pin 4 of the diagnostic/OBDII Port (using a bit of wire or paper clip) which is located by your left knee up under the dash on drivers side. You will then get the engine light, N of the trans, ABS, TCL and ASC (if you have them) flashing.

To read the codes it will be a series of long then short flashes, ie the TCL light flashing _ _ _ _ *pause*. . . . . indicates code 45 (if you get what I mean) There will be a very long pause between each code if you have more than one error code.





When you see (for example 1A) error codes with numbers and letters, these are HEXADECIMAL values. We count in groups of "10" (Base 10) whereas electronic components tend to count in lots of "16" (Base 16), otherwise known as HEXADECIMAL.

So...

1 = 1
2 = 2
3 = 3
4 = 4
5 = 5
6 = 6
7 = 7
8 = 8
9 = 9
10 = A
11 = B
12 = C
13 = D
14 = E
15 = F
16 = "10"



Engine Codes
12 Air Flow Sensor System
13 Inlet temperature Sensor System
14 Throttle Position Sensor System
21 Temperature Sensor System
22 Crank Angle Sensor System
23 TDC sensor <SOHC> or Systematic Camshaft Sensor <DOHC> System Tong
24 Speed Sensor System
25 Atmospheric Pressure Sensor System <T / C>
31 Knock Sensor System
41 Injectors System
44 Ignition Coil, Systematic Power Transistor Unit
-- (No.1 - No.4-cylinder) <DOHC>
52 Ignition Coil, Systematic Power Transistor Unit
-- (No.2 - No.5-cylinder) <DOHC>
53 Ignition Coil, Systematic Power Transistor Unit
-- (No.3 - No.6-cylinder) <DOHC>
61 A / T-ECU And Communication Lines (Torque Reduction Request Signal Line) System
64 FR Alternator System Terminal
71 Vacuum Control Solenoid Valve System <T / C-A / T>
72 Ventilation Control Solenoid Valve System <T / C-A / T>
1A No.1 cylinder accidental fire detection
1B No.2 cylinder accidental fire detection
1C No.3 cylinder accidental fire detection
1D No.4 cylinder accidental fire detection
1E No.5 cylinder accidental fire detection
1F No.6 cylinder accidental fire detection
2C Multicylinder accidental fire detection

Transmission Codes:
11 Non TCL Car – Throttle Position Sensor System - Short circuit
-- TCL Car – Accelerator Pedal Position Sensor System - Short circuit
12 Non TCL Car - Throttle Position Sensor System - Disconnection
-- TCL Car - Accelerator Pedal Position Sensor System - Disconnection
14 Non TCL Car - Throttle Position Sensor System - Sensors misaligned
-- TCL Car - Accelerator Pedal Position Sensor System - Sensors misaligned
15 Oil Temperature Sensor System Disconnection
21 Crank Angle Sensor System Disconnection
22 Input Shaft Speed Sensor System Short-circuit / disconnection
23 The Output Shaft Speed Sensor System Short-circuit / disconnection
26 Stop Lamp Switch system Short-circuit
31 LR Solenoid System Short-circuit / disconnection
32 UD Solenoid System Short-circuit / disconnection
33 2ND Solenoid System Short-circuit / disconnection
34 OD Solenoid System Short-circuit / disconnection
35 RED solenoid system <5 A / T> Short-circuit / disconnection
36 DCC System Solenoid Short-circuit / disconnection
41 Complete Without a fast speed change
42 2-speed variable speed without having completed
43 3 speed complete control of transmission
44 complete 4-speed variable speed
45 complete a 5-speed variable speed <5 A / T>
46 variable speed complete retreat
51 Non TCL Car - Abnormal communication with the engine ECU
-- TCL Car - ASC-ECU abnormal communication
52 DCC solenoid system – Bad System
54 A / T control relay system - Earth short-circuit / disconnection
56 N range lamp system - Earth short-circuit
71 A / T-ECU abnormality

ABS Codes
11 Wheel-Speed Sensor (FR) System (Short or Break)
12 Wheel-Speed Sensor (FL) System (Short or Break)
13 Wheel-Speed Sensor (RR) System (Short or Break)
14 Wheel-Speed Sensor (RL) System (Short or Break)
15 Wheel-Speed Sensor System (Abnormal Signal Output)
16 ABS-ECU Power System (Voltage Abnormal Rise Or Decline)
21 Wheel-Speed Sensor (FR) System
22 Wheel-Speed Sensor (FL) System
23 Wheel-Speed Sensor (RR) System
24 Wheel-Speed Sensor (RL) System
27 2WD/4WD Systematic Detection Switch
33 Stop Lamp Switch (ON disconnection or failure)
41 Solenoid (FR) System
42 Solenoid (FL) System
43 Solenoid (RR) System
44 solenoid (RL) System
**Note: 41 -42 **
**Each item in the corresponding solenoid DOBARUBU drive signal
**if there is no response or an ABS-ECU power system failure
51 Valve Failure Relay ON
52 OFF relay valve failure or power system failure ABS-ECU
53 OFF Motor ABS - ECU failure or power system failure
54 ON failure MOTARIRE
55 Motor System (Pump Motor Sticking), Or Abs-Ecu Power System Failure
63 ABS-ECU system

ASC codes
11 FR wheel speed sensor (Short or Break)
12 FL wheel speed sensor (Short or Break)
13 RR wheel speed sensor (Short or Break)
14 RL wheel speed sensor (Short or Break)
15 wheel-speed sensor system (abnormal signal output)
16 ECU supply voltage abnormality
17 TCL Group 13 H-switch system troubleshooting
21 FR wheel speed sensor system
22 FL wheel speed sensor system
23 RR wheel speed sensor system
24 RL wheel speed sensor system
25 Rear wheel speed sensor system (Simultaneous left and right rear wheel speed sensor burnout)
26 Rear wheel speed sensor system (Both of the rear wheel speed sensor failure)
27 Around the wheel speed sensor system (Both before and after the wheel speed sensor failure)
31 Ignition Switch (IG2) system
32 G-sensor system around
33 Stop Lamp Switch System (ON disconnection or failure)
35 Steering Sensor (ST-1, 2, N) line
36 Steering Sensor (ST-N)
37 Steering Sensor (ST-1, 2) systematic
41 FR Systematic Solenoid
42 FL solenoid system
43 RR solenoid system
44 RL solenoid system
45 FR diagonal cut valve system
46 FL diagonal cut valve system
47 FR Masu Sumi-to-pressure valve system
48 FL-pressure valve system
49 Accumulator valve diagonal line
51 Valve relay system (ON failure)
52 Valve system relay (OFF failure)
53 Motor system (OFF failure)
54 Motor system (ON failure)
55 Motor system (pump motor sticking)
61 A/T-ECU Group and the communications system
63 ECU fail
65 APS system, or TPS
66 TPS or APS system
67 APS system
71 G-sensor system
72 Yaw Rate Sensor System (Disconnection or short)
73 Master Cylinder Pressure Sensor System
74 Yaw Rate G-sensor system
75 Engine ECU
76 Engines and Communications System
77 TCL vacuum or Ventilation Solenoid Valve system
78 Pressure Accumulator Sensor System
81 brake fluid low

AYC Codes
12 voltage power supply (supply valve) system (short or break)
21 FR wheel speed sensor system (short or break)
22 FL wheel speed sensor system (short or break)
23 RR wheel speed sensor system (short or break)
24 RL wheel speed sensor system (short or break)
25 Different Diameter Tires
26 wheel-speed sensor trouble
31 Steer Sensor (ST-1, ST-2, ST-N) System (break)
32 Steer Sensor (ST-N) system (short)
33 Steer Sensor (ST-N) system
34 Steer Sensor (ST-1, ST-2) system (short)
41 TPS system (short or break)
51 before and after the G-sensor system (short or break)
52 G Sensors Around
56 Next G-sensor System (short or break)
61 Stop Position Switch System (break)
65 ABS monitor system (ABS malfunction or break)
71 Proportional Valve System (short or break)
72 Direction Valve (right) System (short or break)
73 Direction Valve (left) System (short or break)
81 Electric Pump Relay System (short or break)
82 Electric Pump Failure
83 Electric Pump Failure

TCL Codes
11 FR wheel speed sensors (or a short break)
12 FL wheel speed sensors (or a short break)
13 RR wheel speed sensors (or a short break)
14 RL wheel speed sensors (or a short break)
15 Wheel speed sensor system (output signal abnormalities
16 Power supply voltage abnormality of the ECU
17 TCL switch circuit system
21 FR wheel speed sensor system
22 FL wheel speed sensor system
23 RR wheel-speed sensor system
24 RL wheel speed sensor system
25 Rear wheel speed sensor system (left and right rear wheel speed sensors simultaneous disconnection)
26 Rear wheel speed sensor systems (both of the rear wheel speed sensor failure)
27 Around the wheel speed sensor systems (both before and after the wheel speed sensor failure)
31 Ignition Switch (IG2) strains
32 Circuits around the G sensor system
33 Stop lamp switch strains (ON injury or burnout)
35 Steering sensor (ST-1, 2, N) system
36 Steering sensor (ST-N) strains
37 Steering sensor (ST-1, 2) system
41 FR solenoid valve system
42 FL solenoid valve system
43 RR solenoid valve system
44 RL solenoid valve system
45 FR Cut valve diagonal strains
46 FL Cut valve diagonal strains
47 FR Masu Sumi-pressure valve system
48 FL Masu Sumi-pressure valve system
49 Pressure valve (FL-FR) system
51-Valve relay system (ON failure)
52-Valve relay system (OFF order)
53 Motor relay strains (OFF order)
54 Motor Relay system (ON failure)
55 Motor system (pumps, motors sticking)
61 A / T-ECU and the communication system
63 ECU fail
65 APS system, or TPS
66 APS or TPS system
67 APS system
71 system next sensor circuit G
72 Yaw late sensor circuit system (or a short break)
73 circuit master cylinder pressure sensor system
74 Yaw late sensor or G sensor system
75 Engine ECU strains
76 Systematic communication with the engine ECU
77 TCL vacuum system or ventilation solenoid
78 Accumulator pressure sensor circuit system
81 Shortage of brake fluid

[Davezj]

Good find,
Not sure if any differ from what we alady have here,
http://www.clubvr4.com/forum/showthr...agnostic+codes
But it looks well laid out, I will have to have a read of the descriptions and do a compare.
This list I compiled was from the jap workshop manual that I translated from Japanese to English.

[bakerboy-2007]

Lol yea looks the same

I found it while tearing what's left of my hair out I've got codes

77 TCL and engine 72 I've changed the solenoids and canister and all the hoses still same codes

Also an annoying abs fault on rear drivers side ring or sensor (just pulled the fuse for now)

And really picking my head is my ayc problem

On start up the white letters and the 3 bars light but no red light, when driving no lights at all, I've checked both the fuses but all seems ok

I though I know what to do next so I thought check all other pipes and just found a big dint possible crack in my inter cooler

[Davezj]

That is a bummer about intercooler, but i don't think that will the error codes.

Did you swap the solenoids for new ones or second hand one as the replacement could be dodgy. Same applies to the grey vacuum canister.

As for the no red AYC light I would have thought the bulb has been taken out to hide something like a non working AYC pump, which would stop the green bars lighting up when driving.
Easiest way to check this is to remove the dash display. 2 screws at the top of the Shroud steering lowered pull out shroud watch the dimmer switch. Then there should be 4 screws to take dash display out.
Check the bulbs.

[bakerboy-2007]

Yea mate checked all bulbs in place I swapped the battery bulb over and still nowt :s

[bakerboy-2007]

Just a thought is there an ecu for the ayc??

[SEAN-NZ]

yes, i think its on the left side of the passenger side of car, if i remember right

[Nick Mann]

Yes, behind the glove box. You do remember right!

[bakerboy-2007]

Nick you are a legend will pm you in a mo

If the plug was pulled on this would the green lights still light on engine start but the ayc be inactive??

[Nick Mann]

I don't think that the green lights would come on at all on start up with the ayc ecu disconnected but I don't know for sure.

[kares_leni]

hi there I just did this and ABS light was giving me codes they are 13, 14 ,32 but I am looking for engine codes how to swich to engine light to show codes becouse my problem it is not from this sensors which codes show
13,14 RR wheel speed sensor (Short or Break)
32 32 G-sensor system around
the problem is after I start the car whe push the gas pedal slowly it goes up to 2-3k rpm and goes down but I AM STEEL pushinng the pedal it goes up and down the car is undrivible I did chenge fuel filter first, now I am wating for Ignition Coils to come becouse the midle one the body is craked I hope this to be the problem but I do not thik so ,the sparks are new 2.3 mounts, cables are magnesor 85 they are ok, if it not the ignition coils I am in troble if some body has other IDEAS will be greate the maf sensor apears to be good I check itwith multimetr
thanks in advance

[Davezj]

All codes from all the available light flashing are active at the same time. If there was a recorded engine code it would be flashed up at the same time as the abs code.

Sent from my MI 5s using Tapatalk

[Davezj]

hi there I just did this and ABS light was giving me codes they are 13, 14 ,32 but I am looking for engine codes how to swich to engine light to show codes becouse my problem it is not from this sensors which codes show
13,14 RR wheel speed sensor (Short or Break)
32 32 G-sensor system around
the problem is after I start the car whe push the gas pedal slowly it goes up to 2-3k rpm and goes down but I AM STEEL pushinng the pedal it goes up and down the car is undrivible I did chenge fuel filter first, now I am wating for Ignition Coils to come becouse the midle one the body is craked I hope this to be the problem but I do not thik so ,the sparks are new 2.3 mounts, cables are magnesor 85 they are ok, if it not the ignition coils I am in troble if some body has other IDEAS will be greate the maf sensor apears to be good I check itwith multimetr
thanks in advance

Easy wAy to see if ignition coil is breaking down is to spray the coil packs with water from a spray bottle. If the coil pack doesn't give visible breakdown when the water is sprayed. The coil pack is good.
It is easier to see the breakdown at night.
I can spray all of my current coil packs and they is no sparking at all.
I tested my spare coil packs a few days ago one at a time on my car and 5 out of my 7 spares broke down. 2 of my coil packs on my car were breaking down so I no longer have any spares.
I am thinking of putting an insulating covering over the faulty coil pack and see if the makes them work.
I will come with a conformal coating used in the PCB fabrication industry to combat unwanted discharge.
I design PCB for a living, and I can't see why it would not help the coil pack work.
All you are doing is making sure the required spark occurs where you want it to. If the coil pack is sparking in a place you do not want it to it means the coil pack is working and is sparking as it should do. It is just in the wrong place. An insulating coating should make the coil pack work.


Sent from my MI 5s using Tapatalk

[kares_leni]

thanks Dave my midle coil is sparking from the body thanks to your waY with the spray water I bought one coil (shud be 3 of them )from australiq it is not cheep but it is wort it but the problem with stalling it is there again and I did find the problem , IT was the MAF REPLACE IT with evo 4 MAF and now drive perficly now I have to find where to send the old for reciclation any info ?
thans for your advise.Now I am happy to drive it again this car is got under my skin if it is not allright I am not to DEVIL car.